Pyrite Flotation Zinc

Reverse flotation of pyrite from a zinc-concentrate using ...

1995-10-1  A mobile flotation facility, based on two 5 L minicells equipped with on-line monitoring of pH, dissolved oxygen and pulp potential, was used to study flotation of pyrite from zinc concentrate (i.e. reverse flotation) at the Trout Lake circuit of Hudson Bay

More

Depression of pyrite in the flotation of high pyrite low ...

2010-1-1  In this research work, selective depression of pyrite in the flotation of a low-grade lead–zinc ore containing 31% pyrite was investigated in the absence and presence of Acidithiobacillus ferrooxidans. Pyrite was significantly depressed with these bacteria using the optimum dosage of reagents.

More

Method of floatation of copper-zinc-pyrite ore (versions)

1. Method of flotation of copper-zinc-pyrite ore, including grinding in an alkaline medium, air conditioning with reagents - collectors and frothers, collective copper-zinc flotation to produce collective concentrate containing copper minerals and natural-activated sphalerite, and tails, characterized in that as the collector used is supplied in the following sequence composition selective ...

More

THERMOMECHANICAL ASPECT OF SELECTIVE

2016-1-10  which mutilates flotation process. It is known that zinc cycle of copper–zinc ore flotation uses xanthate modifications that are not selective relative to pyrite. In view of the aforesaid, it is re-quired to design a process flow chart toward higher efficiency of separation of zinc minerals and pyrite in the zinc cycle of flo-tation.

More

Flotation of Pyrite - 911metallurgist

2017-5-3  Sodium silicate was somewhat effective in causing a differential or selective flotation of copper, as chalcopyrite from pyrite by keeping pyrite from floating. Sodium

More

Optimization of Conditions for Processing of Lead–Zinc ...

2021-11-9  Bagheri et al. studied the recovery of sphalerite and pyrite from old tailings with a high zinc content. The effect of various flotation agents (collector, auxiliary collector, depressor, activators and foaming agent) on the characteristics of flotation was studied.

More

Critical importance of pH and collector type on the ...

2021-2-4  In both lead and zinc circuits, pyrite is the main sulphide gangue mineral. It is critical to decrease the presence of iron (Fe) and Zn in the lead concentrate during the flotation of galena.

More

Effect of Physisorption of Collector on Activation of ...

2020-10-19  Naing, Lin U., Increasing the Selectivity of Flotation of Pyrite Copper-Zinc Ores Using Pyrite Flotation Modifiers Based on Ferrous Iron Compounds, Cand. Tech. Sci. Thesis, Moscow, 2015. 21. Kakovsky, I.A., Study of the Physicochemical Properties of Some Organic Flotation Agents and Their Salts with Heavy Nonferrous Metal Ions, Trudy IGD AN ...

More

(PDF) New collectors for sphalerite flotation

flotation of zinc from a Canadian copper-rougher-tails. ... The general order of mineral floatability with these reagents is chalcopyrite = chalcocite > covellite ≥bornite >> pyrite. The ...

More

Flotation Reagents - Mineral Processing Metallurgy

2016-6-8  An alkalinity modifier regulator and depressor of pyrite. Used extensively in lead-zinc flotation. Liqro: A Crude tall oil, bi-product from paper pulp manufacture.

More

Method of floatation of copper-zinc-pyrite ore (versions)

1. Method of flotation of copper-zinc-pyrite ore, including grinding in an alkaline medium, air conditioning with reagents - collectors and frothers, collective copper-zinc flotation to produce collective concentrate containing copper minerals and natural-activated sphalerite, and tails, characterized in that as the collector used is supplied in the following sequence composition selective ...

More

Sulfidation roasting of zinc leaching residue with pyrite for ...

2020-5-15  Zinc leaching residue (ZLR) contains high content of valuable metals such as zinc and iron. However, zinc and iron mainly exist in the form of zinc ferrite, which are difficult to separate and recover. This study proposed a new process involving sulfidation roasting, magnetic separation and flotation to recover zinc and iron in ZLR. Through sulfidation roasting of ZLR with pyrite, zinc and ...

More

THERMOMECHANICAL ASPECT OF SELECTIVE

2016-1-10  which mutilates flotation process. It is known that zinc cycle of copper–zinc ore flotation uses xanthate modifications that are not selective relative to pyrite. In view of the aforesaid, it is re-quired to design a process flow chart toward higher efficiency of separation of zinc minerals and pyrite in the zinc cycle of flo-tation.

More

Sulfidation mechanism of ZnO roasted with pyrite ...

2018-6-22  Zinc is an important base metal required for various applications and is mainly recovered from primary sulfide ores via flotation and metallurgical processes 1.With the rapid development of ...

More

Critical importance of pH and collector type on the ...

2021-2-4  In both lead and zinc circuits, pyrite is the main sulphide gangue mineral. It is critical to decrease the presence of iron (Fe) and Zn in the lead concentrate during the flotation of galena.

More

Adriatic Metals plc Pre-Feasibility Study Metallurgy and ...

2020-10-15  Pyrite Flotation. The purpose of the pyrite flotation circuit will be to recover pyrite prior to the barite flotation circuit. The zinc flotation tailings report to a conditioning tank, where sulphuric acid, copper sulphate, collector, and frother are added. The slurry will be then pumped to the pyrite rougher flotation cells. Pyrite Rougher ...

More

Recycling of process water Effect of calcium and sulphate ...

2016-9-30  pyrite flotation but selectivity against zinc is adversely affected in flotation of copper and zinc when sulphate ions concentrations in the water is more than 100 mg/l. In Laisvall concentrator deterioration of lead flotation and over frothing was experienced due to precipitation of calcium carbonate from the mine water in pipes and spray nozzles.

More

Pyrite depression by dextrin in flotation with xanthates ...

2018-10-4  2004). Pyrite depression with dextrin occurs around pH 8 so using dextrin could lower the pH in flotation processes operating at high pH such as the flotation of copper in porphyry ores and flotation of zinc in polymetallic base-metal sulfide ores. Furthermore, dextrin could be used as a pyrite

More

乙硫氮作捕收剂时无机调整剂加药顺序对典型硫化矿物浮选的 ...

Abstract:The effect of the addition order of inorganic regulators (zinc sulfate, copper sulfate, sodium sulfite and sodium sulfide) on the flotation of typical sulfide minerals (chalcopyrite, galena, sphalerite and pyrite) was investigated using diethyldithiocarbamate as collector. ...

More

磨矿和浮选过程中黄铁矿电化学行为的研究进展

2020-6-29  Mu Y F, Peng Y J, Lauten R A. The depression of pyrite in selective flotation by different reagent systems-A literature review. Miner Eng, 2016, 96-97: 143 doi: 10.1016/j.mineng.2016.06.018 [36] Janetski N D, Woodburn S I, Woods R. An electrochemical

More

THERMOMECHANICAL ASPECT OF SELECTIVE

2016-1-10  which mutilates flotation process. It is known that zinc cycle of copper–zinc ore flotation uses xanthate modifications that are not selective relative to pyrite. In view of the aforesaid, it is re-quired to design a process flow chart toward higher efficiency of separation of zinc minerals and pyrite in the zinc cycle of flo-tation.

More

An Electrochemical Study of Surface Oxidation and ...

2018-5-8  sulphate on the floatability of pyrite at pH 9.0 and reported that zinc sulphate depressed pyrite flotation at a potential of 0.275 V (SHE) but had no or little effects at lower potentials. They speculated that this was a result of less hydroxide groups formed on pyrite surface for zinc hydroxide attachment at

More

Flotation of sphalerite and pyrite in the presence of ...

2016-11-28  Pyrite is one of the major diluents of copper, lead and zinc concentrates. One explanation for the high flotation of pyrite in alkaline pH conditions is its inadvertent activation by copper either dissolved from copper minerals present in the ore or added in the zinc circuit to activate the flotation of sphalerite Bushell and Krauss, 1962 ...

More

Electrochemistry of lead and zinc sulfide mineral flotation

The effects of oxidation potential (Eh) and zinc sulphate on the separation of chalcopyrite from pyrite were investigated at pH 9.0. The flotation recovery of these minerals is Eh dependent with ...

More

Sulfidation roasting of zinc leaching residue with pyrite

2020-5-10  This study proposed a new process involving sulfidation roasting, magnetic separation and flotation to recover zinc and iron in ZLR. Through sulfidation roasting of ZLR with pyrite, zinc and iron were converted into ZnS and Fe3O4. The effects of pyrite dosage

More

Correlation of Surface Adsorption and Oxidation with a ...

2018-2-13  By virtue of high dosage of lime and collector sodium diethyl dithiocarbamate (DDTC), pyrite and zinc minerals are depressed, allowing the galena to be floated. However, there have been significant conflicting reports on the flotation behavior of galena at high pH.

More

Pyrite depression by dextrin in flotation with xanthates ...

2018-10-4  2004). Pyrite depression with dextrin occurs around pH 8 so using dextrin could lower the pH in flotation processes operating at high pH such as the flotation of copper in porphyry ores and flotation of zinc in polymetallic base-metal sulfide ores. Furthermore, dextrin could be used as a pyrite

More

Recycling of process water Effect of calcium and sulphate ...

2016-9-30  pyrite flotation but selectivity against zinc is adversely affected in flotation of copper and zinc when sulphate ions concentrations in the water is more than 100 mg/l. In Laisvall concentrator deterioration of lead flotation and over frothing was experienced due to precipitation of calcium carbonate from the mine water in pipes and spray nozzles.

More

乙硫氮作捕收剂时无机调整剂加药顺序对典型硫化矿物浮选的 ...

Abstract:The effect of the addition order of inorganic regulators (zinc sulfate, copper sulfate, sodium sulfite and sodium sulfide) on the flotation of typical sulfide minerals (chalcopyrite, galena, sphalerite and pyrite) was investigated using diethyldithiocarbamate as collector. ...

More

First Quantum Minerals Ltd. - Our Operations

This is followed by conventional flotation, consisting of three sequential flotation circuits, one each for copper, zinc and pyrite. Outlook The life of the mine has been extended into June 2021 with an assumed lower copper cut-off grade.

More